Owner complaints, recalls, fuel economy and safety ratings from public NHTSA and EPA data, updated Oct 17, 2026.
Fuel economy
23–25 mpgcombined; city 20–22, highway 27–31; every version of this model year
Five years of fuel
$12,990–$17,500U.S. average; Ohio $11,610–$16,490 at local prices; every version of this model year; fuel only, not other costs of owning it; 15,000 miles a year, at EIA fuel prices for the week of Oct 12, 2026
NHTSA overall safety rating
Not ratedNHTSA has no overall rating for this year
NHTSA's VIN data lists these trims for the 2006 Cobalt. A trim's engine and numbers are shown as its own only where EPA names versions after the trim and no other version could be it; "seen with" means a source shows that engine on the trim, not that it was the only one. Recalls and complaints cover the whole model year: whether a recall applies to a car depends on its VIN, on NHTSA's recall lookup.
Owners have filed 2,330 complaints with NHTSA about the 2006 Cobalt. These are unverified owner reports, counted by the part of the car they name; one complaint can name several parts. Counts aren't adjusted for how many were sold, so they don't show how reliable a car is.
Complaints by part of the car
Part
Complaints
Crashes
Fires
Injuries
Steering
1,299
78
4
133
Electrical system
412
36
6
122
Fuel/propulsion system
255
1
3
1
Fuel system, gasoline
215
4
2
2
Air bags
146
59
1
47
Power train
137
12
0
5
Engine
93
12
3
5
Structure
51
6
1
4
Suspension
51
5
0
3
Vehicle speed control
48
6
1
3
Engine and engine cooling
43
3
1
0
Unknown or other
40
5
0
4
19 more parts
Latches/locks/linkages
38
1
0
2
Electronic stability control (ESC)
29
4
0
2
Service brakes
26
12
2
7
Service brakes, hydraulic
25
6
0
2
Equipment
17
1
1
0
Exterior lighting
17
3
0
2
Traction control system
14
0
0
0
Visibility
14
1
0
0
Seat belts
8
5
0
6
Wheels
7
2
0
2
Fuel system, other
5
0
0
0
Tires
5
1
0
0
Interior lighting
4
0
0
0
Seats
3
1
0
2
Equipment adaptive/mobility
2
0
0
0
Visibility/wiper
2
1
0
0
Child seat
1
0
0
0
Forward collision avoidance
1
0
0
0
Lane departure
1
0
0
0
Complaints by model year
Newer years have had less time to collect complaints, and counts aren't adjusted for sales, so a shorter bar doesn't mean a more reliable year.
NHTSA lists 5 recall campaigns for the 2006 Cobalt over its history. Campaigns are matched by model and year, so each one may apply to a given car, and its repair may already be done: check a VIN on NHTSA's recall lookup for the open recalls on that exact car.
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2005-2010 CHEVROLET COBALT AND MODEL YEAR 2007-2010 PONTIAC G5 VEHICLES EQUIPPED WITH ELECTRIC POWER STEERING. THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING ASSIST THAT COULD OCCUR AT ANY TIME WHILE DRIVING.
Risk: IF POWER STEERING ASSIST IS LOST, IT WOULD REQUIRE GREATER DRIVER EFFORT AT LOW VEHICLE SPEEDS, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ELECTRIC POWER STEERING MOTOR FREE OF CHARGE. OWNERS ARE BEING NOTIFIED ON A ROLLING BASIS BETWEEN MARCH 29 THROUGH NOVEMBER 2010. A COPY OF THE MAILING SCHEDULE IS LOCATED IN THE RECALL FILE. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Risk: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF-MOUNTED SIDE IMPACT AIR BAGS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, 'OCCUPANT PROTECTION IN INTERIOR IMPACT.'
Risk: IN A CRASH, HEAD IMPACT PROTECTION MAY BE INADEQUATE.
Remedy: DEALERS WILL INSTALL ENERGY ABSORBING PLASTIC TO THE HEADLINER TRIM TO REDUCE THE SEVERITY OF HEAD IMPACTS IN A CRASH. THE RECALL BEGAN ON MARCH 21, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Carmakers sent NHTSA 796 service bulletins and notices that cover the 2006 Cobalt, the latest on Jul 18, 2025. They tell dealers how to fix known issues.
The parts they mention most: equipment (341), electrical system (188), engine and engine cooling (92), equipment adaptive/mobility (54), power train (46).
NHTSA defect investigations
Opening an investigation isn't a finding of a defect. Outcomes are as NHTSA's summary states them. A recall is shown as an investigation's outcome only where NHTSA's summary names it; other recalls NHTSA's file lists with it are marked as listed, not caused.
Investigation
Part
Opened
Status
Preliminary evaluation PE10005 Electric Power Steering Failure · covers 2 makes
The owner's manual gives the oil and how often to change it. We show oil facts only once we've checked them against the manual, and we haven't yet for the 2006 Cobalt.
EPA class: subcompact cars. Each version EPA tested:
Swipe the table sideways for more columns.
Version
Engine
Transmission
Fuel
City / hwy / comb
Cobalt Front-Wheel Drive
2.2 L, 4 cyl
Manual 5-spd
Regular Gasoline
22 / 31 / 25
Cobalt Front-Wheel Drive
2.4 L, 4 cyl
Manual 5-spd
Premium Gasoline
22 / 31 / 25
Cobalt Front-Wheel Drive
2.2 L, 4 cyl
Automatic 4-spd
Regular Gasoline
21 / 29 / 24
Cobalt Front-Wheel Drive
2.4 L, 4 cyl
Automatic 4-spd
Premium Gasoline
21 / 29 / 24
Cobalt Front-Wheel Drive
2.0 L, 4 cyl, supercharged
Manual 5-spd
Premium Gasoline
20 / 27 / 23
Sources and dates
U.S. EPA fuel economy data, file of Sep 29, 2026
NHTSA owner complaints, file of Oct 17, 2026
NHTSA recalls, file of Oct 17, 2026
NHTSA manufacturer communications, file of Oct 17, 2026
NHTSA defect investigations, file of Oct 17, 2026
NHTSA 5-Star Safety Ratings, file of Aug 7, 2026
U.S. Energy Information Administration, file of Oct 12, 2026
Fuel cost: EPA mpg with fuel prices for the week of Oct 12, 2026 and electricity prices for Jul 2026. Source: U.S. Energy Information Administration (Oct 2026). Complaints are unverified reports owners filed with NHTSA. About the data